Aspen Avionics E5 | Brant Aero Job in Littleton - Arapahoe County - CO Colorado - USA , 80161. One pilot told us he had to seriously beef up his instrument-flying technique because he could now see many minor roll excursions on his Aspen that were simply too small to appear on his vacuum-powered AI. The problem, the SAIB said, appears to be related to the ADS-Binterface, and the FAA recommended that operators suspend night and IFR operations until the problem has been straightened out. Littleton - Arapahoe County - CO Colorado - USA , 80161. I wont turn this into a this is better than that, but one factremains true: Rarely- if ever - doesa G500/GADxx product haveanywhere near these issues; nor do theyfail todisplay anything for which they wereintended. Aspen, CO. Posted: 13 hours ago. Since the E5 uses pitot and static pressure input as part of the AHRS attitude calculations, loss or corruption of the pitot or static pressure (perhaps an iced up pitot tube) can influence the accuracy of the displayed attitude data. The AD goes into effect on Aug. 17, 2020, and is open for public comment until Sept. 14, 2020. The FAA has issued a Special Airworthiness Information Bulletin (SAIB) to alert pilots to a potential problem with the Aspen Evolution PFD. Even if the AD is explicitly about ADS-B traffic which the OP specifically listed as not even being fed into the system? Designed by Elegant Themes | Powered by WordPress, What Instrument Pilots Need to Know About Flying Ice-Free in Winter, Whelen Engineering to Acquire LoPresti Aviation. While some report they are still not comfortable with the Aspen, the majority were comfortable flying it in five hours or less. This website contains many older reviews. It estimates the total fix time at half an hour, mentions that Aspen is working on a permanent fix for the problem so its features can be turned back on, and in essence says to do this now. Nearly half the respondents reported problems of one kind or another, but there was no smoking gun and many of these were in the earlier deliveries. New Aspen E5 - In-Flight Crash and Reset - Avionics/Panel Discussion The lower half of the EFI is the navigation display, which has 360-degree and ARC compass rose displays. Avionics; Aspen Owners Survey: An Overall Thumbs Up After some growing pains, this retrofit is performing well. Logs seem clean to me but Aspen has yet to review and make a root cause determination. Check out the capabilities and the information available on Aspen Avionics displays when shooting an approach. This is what it is supposed to do per the STC. Legacy attitude and airspeed instruments must be maintained with the installation, but the removed VSI or HSI have been bought back by some installers for a customer credit. FAA Global AMOC Aug 2017*. Can you post who you have been dealing with, and then I can do the same. Im confused about what is going on here. (Courtesy of Aspen Avionics) Listed on 2023-03-03. First long xc I was on after install was with my IFR instructor. Sr. Electronics Engineer,Avionics Job Littleton Colorado USA,Engineering Sign in to continue reading, FAA issues a Special Airworthiness Information Bulletin to alert pilots, By Plane & Pilot Updated November 29, 2018 Save Article. When Aspen Avionics announced its retrofit PFD system in 2007, we were impressed with the designs ingenuity and its workable price point. Aspen Avionics taxis toward public launch - Albuquerque Journal For this report we put the new E5 on our test bench to see how the feature set compares with other Evolution displays. If you need help finding a dealer in your area, I will be happy to help. A lot has been written about the size of the display. . It doesnt follow the magenta [line] too well on tight curves. In our estimation, even basic E5 installations might come in north of $7000. Went for a test flight after an install of an Aspen EFD1000 in a Cessna 310. Additionally, the first click when the knob is turned (or the first press on the knob) wakes up the knobs function. The good news is that Aspen support was praised. Aspen Avionics introduced a new online learning course for its Evolution Pro MAX flight display series at AirVenture 2021 in Oshkosh, Wisconsin. My Bendix/King HSI was giving me problems. The inclusion of leading technology companies like Aspen Avionics helps the AIRO Group further capitalize on the attractive [aerospace and defense] market trends around autonomy, avionics, and military training, said Chris Gidden, managing director and global head of aerospace and defense for Stephens, a financial advisor retained by the AIRO Group. Further, the size of the attitude gyro portion of the display is larger than the Castleberry electric, flight-director gyro it replaced. We are currently recruiting an Avionics Maintenance Technician for one of our clients. Interim Action:We consider this AD interim action. As for installation effort, thats tough to nail because every aircraft is unique, but Aspen told us that 30 hours (minimum) of shop labor is a safe bet for the typical E5 installation. A good place to start is with Andy Smith from Aspen. Im pretty sure the ea100 works with many older AP systems that the GAD units are not certified for. Apply for a Total Aviation Staffing, LLC Avionics Maintenance Technician job in Aspen, CO. This is thanks to a new regulatory certification process that sidesteps the pricey and time-consuming TSO process in favor of an STC. Aspen problems - Avionics/Panel Discussion - Mooneyspace During the time of the reset, the pilot might not have any EFD displayed information including access to altitude and airspeed for up to one minute. The MAX uses the new display and processor technology (the same thats used in the E5), plus it also includes the ACU for advanced autopilot interfaces as standard. Honeywell International Dynon Avionics L-3 Communications Holding Astronics Corporation Aspen Avionics Genesys Aerosystems Rockwell Collins Esterline Technologies Avidyne Corporation Garmin Ltd. The result is an Belvoir Media Group, LLC. AOPA has welcomed Aspens contributions to aviation safety and modernization, and installed Aspens first FAA-certified primary flight display in the AOPA 2008 Get Your Glass Sweepstakes airplane. Familiarity with avionics manufacturers such as Garmin, Bendix-King, Honeywell, Avidyne, Aspen Avionics, Freeflight . After some quick help from Aspen, it was discovered that the Z axis of the Magnetometer Guass sensor in the RSM had failed. Unlike other Aspen displays, the E5 only has one page, so youll always view attitude and heading data. @PeteMc The aircraft that was referenced was worked on June last year. EFD1000 E5 Dual Electronic Flight Instrument (EFI) Install Manual 1) Use RSM doubler as a template to mark shim stock. I thought you purchased a lifesaver from the reaper? Edit, if it matters mine is also paired to an ifd440, That is interestingso far, I've been able to find 4 Aspen E5 customers with this issue.all seem to have ifd440s. Specifically, this SAIB notifies owners and operators of temporary loss of all flight display information due to blanking during reset. Now it seems that I have to rebuy the system again in repairs? GSS Software Developer, Sr - Aspen Technology - LinkedIn Brant Aero installed an Aspen E5 in my Piper Seneca II in May 2019 to replace a failed DG and working AI. If you are interested in the Avionics Maintenance Technician apply today! We install avionics from a number of manufacturers including Garmin International, Aspen Avionics, and Genesys Aerosystems. He has posted a company statement on Beechtalk and Mooneyspace about the reboot issue and what they are currently doing to address the issue. The fact that now itsa different box than whats on the AD illustratesthat Aspen hasvery, I do think part of the reason Garmin has fewer failures is the closed architecture that allows them to control what is interfaced with the pfds. Courtesy of Aspen Avionics. Unlike higher-end Aspen displays, the E5 wont display synthetic vision or Aspens software-based angle of attack data. There are notable exceptions, but they seem to be clustered in the earlier installs, which is the trend we want to see. Thats because the E5 can use GPS groundspeed instead of indicated airspeed as part of its overall AHRS solution. additional data such as true airspeed or a wind vector. In agreement with your post although I don't think you need to have dual E5s for reliability. Quality control seems like a major problem. While this issue seems to be dissipating (although not completely gone), its another reason to go with a shop thats done several installations. Familiarity with avionics manufacturers such as Garmin, Bendix-King, Honeywell, Avidyne, Aspen Avionics, Freeflight . . Was $5395.00 . - I have looked at the disgnotics page and see nothing out of what I would expect to be normal SB2018-01, dated November 21, 2018 (SB2018-01); except, where SB2018-01 specifies contacting an Aspen Avionics dealer to disable the ADS-B In function, this AD requires disabling the ADS-B IN function using a method approved in accordance with paragraph (h) of this AD. B) Reboot the avionics stack in a hold or something and then re-program the approach and hope the pitot issue clears up for the Aspen. Not sure if the E5 is governed by the same STC for IFR flight. Aspen have been very supportive and I have been compensated for the Avionics shop time in reinstalling the RSMs which is not a trivial operation. They market it somewhat that it gives GPS backup, which it does not. Coming Soon: The Semi-Professional Pilot. But its not a big deal. I think@LANCECASPERhas the ifd units and max displays. I have tried - Founded in 2004 by aviation enthusiasts, Aspen Avionics has a history of punching above its weight, having long battled Garmin to gain a significant share of the general aviation avionics market. In several cases, part of the motivator was the cost of the alternative. I'll probably sell it at a loss and install dual G5s on my dime when the GFC500 is available for short bodies. Aspen / Century and all analog Auto pilotProblems - ABS 3rd reset) On departure at ~5k ft in Dec - high power/RPM:::Logs downloaded and sent to Aspen. Aspen Avionics President and CEO John Uczekaj, who joined the AIRO Group leadership team, voiced enthusiasm for the development in the same press release: As a recognized innovator in the general aviation segment, Aspens inclusion in the AIRO Groups diversified company portfolio not only helps strengthen Aspen Avionics current business lines but opens up opportunities in other aerospace markets that will enable future growth and innovation, Uczekaj said. See if any of this link matches your experience That is it !!! Really excited about the new hsi E5 upgrade. The rear chassis also houses a rechargeable (and field-replaceable) backup battery, a 44-pin D-Sub connector and a cooling fan. Each press of this CDI nav source button selects the next available nav source, cycling through all available sources in a round-robin sequence. Aspen users have waited years for this solution and it's built into the E5 and the new MAX. Aspen NexNav Mini. The hard part isnt getting used to the Aspen. Few minutes/seconds later AHRS light will extinguish and A/P can be re-engaged. Aerospace Engineer, Engineering Design, Electrical Engineer, Mechanical Engineer. On Tue, Apr 26, 2022 at 10:00 AM Andy Smith wrote: I read the post and the extensive troubleshooting that you have gone through and changing out different boxes. The coolest jobs on this planet or any other are with Lockheed Martin Space. 1 review for Aspen Avionics E5. Aspen Avionics specializes in bringing advanced technology and capability into general aviation cockpits--and budgets. SA10822SC. There is a thread on Beechtalklink that goes over the issues. Required Actions (a section of the AD) Affected units are Aspen's Evolution Flight Display EFD1000 Primary Flight Display (PFD), EFD1000 Multi-Function Display (MFD), and EFD1000 Emergency Backup . I cant believe its a hardware problem soundsmore like a software incompatibility issue. Powered by Invision Community. None of this seems to matter tho. Aspen EFD1000 E5: Low Cost, But Stark - Aviation Consumer Aspen Avionics products are available from Pacific Coast Avionics, your avionics and pilot supply superstore. Install an Aspen unit primarily if you need the functionality (slaved DG, GPSS). One item that did come up in our survey is that while the Aspen has an internal GPS, it has no direct-to function as it has no database. I hope you can understand and empathize with me of the frustration that I have had with Aspen for about 330 hours of flight. PFD Primary flight display instrument panels AD Affects Aspen Flight Displays: UPDATE from Aspen Avionics Unless otherwise noted, these reviews carry product pricing from the time of the original review. Sent to Aspen from external source. The overall satisfaction with the Aspen system seems quite high. Powered by Invision Community. Airworthiness Directive (AD) 2020-16-08, limiting operation of aircraft equipped with certain Aspen Avionics flight displays to Day/VFR operation only, was published July 31, 2020. Would be possible for sure though, just not fun. As for the entry-level E5, we think its a credible and affordable product to compete with Garmins G5 if you can live with a no-frills feature set. The Dynon HDX system is equally as good in my opinion (Especially in the experimental world when you don't have to install the D10A as a backup- the g3x/G5 integration is a lot slicker admittedly) and the Dynon AP is pretty powerful- especially with the advanced FD panel and connected to the avidyne GPS navigator. As mentioned in my email, it is best to have an Authorized Dealer take a look at the system and diagnose the problem. Pilots Facing Retests After Incompetent Examiner Revealed. I have had no problems since then., Its worth noting that 12 percent of those reporting needed to relocate other equipment or cables to make the Remote Sensor Module (RSM) work properly. If you have an account, sign in now to post with your account. In many cases, its quite warm or even hot to the touch in operation. AspenTech: Knowledge Base 2 different Aspen 1000 PFD's 3 different ACU's Replaced Ethernet cable Checked wiring. Feb 20, 2023 (The Expresswire) -- Global Aircraft Cockpit Display Market offers an [Industry Insight Report 2023 . This AD requires disabling the ADS-B In function in each installer menu by changing the RS-232 INPUT for the bus connected to the ADS-B In to NONE. The design approval holder is currently developing a modification that will address the unsafe condition identified in this AD. Not saying that is it but its just interesting. With 32,768 colors, a 400 by 760 display resolution and high-intensity white LED backlighting, the 6.0-inch diagonal TFT active matrix LCD screen is noticeably more crisp and brighter than the first-gen units. I am one of the core software engineers in the Subsurface Science and Engineering (SSE) group working on next-generation cloud and desktop (Windows/Linux) software in the oil and gas industry and green energy solutions. Also Aspen does not have repair capability, so does that mean the equipment is being manufactured overseas? The FAA has issued a Special Airworthiness Information Bulletin (SAIB) to alert pilots to a potential problem with the Aspen Evolution PFD.The FAA said the condition doesn't currently warrant an Airworthiness Directive, and it offered suggestions to avoid the problem. The cost to overhaul and reinstall the 25-year-old HSI system was probably half of what this new system was going to be, with hoped-for increases in reliability and duplication of attitude information., This can open a huge can of worms. Click here or above and get a free newsletter, plus choose your download: 172 Owners Guide, 182 Owners Guide, or Digital Magazine. Avionics/Panel Discussion ; Aspen problems Aspen problems. FAA approves removal of attitude indicator with installation of Aspen BIO: Uczekaj has more than 35 years of experience in the avionics industry, starting out as an engineer at Boeing and moving into key . Aerospace Engineer, Avionics Engineer, Electrical Engineer, Systems Engineer. I don't trust it. Page 74: Acu/Acu2 Installation. Editor in Chief Larry Anglisano has been a staple at. Intelligent placement of your backup instruments is worth serious thought if youre putting in the Aspen. Aspen Owners Survey: An Overall Thumbs Up - Aviation Consumer - E5 has a backup battery but never "goes to battery", ie like in a loss of power situation HDG is always the default setting for the right knob-the way it should be, given the frequency with which its used. Avionics Manager job at GPAC in Opelika Alabama Aspen Avionics specializes in bringing the most advanced technology and capability into General Aviation cockpitsand budgets. Let that sink in. Sure, on the Airbus I enjoy a display that is twice as large. This accessory adds $1000 to the $4995 base price. And lets be honest we practice partial panel during ifr training for a reason. What Are the Best Aviation Headsets of 2020. Sent from my iPhone using Tapatalk Pro. Aspen Avionics AP Problems - YouTube So having said that it gets pretty expensive to replace boxes on my dime. The RSM's had a problem with water intrusion they updated them a couple years ago (changed the potting on the bottom) and it got a bit better. For instance, the left and right bezel knobs are designed to provide immediate operation, yet are designed with fail-safe so you dont inadvertently cause an unwanted operation. No matter which Aspen you chose, youll need to consider a backup strategy. The system is approved for over 650 aircraft, but we saw the vast majority in medium- to high-performance piston singles. 2nd reset) In cruise at ~8k ft in Sept - cruise power/RPM:::E5 replaced again by Aspen + New (blue) shielded RSM cable Nov - cable length less than 12 feet. Plane and Pilot builds on more than 50 years of serving pilots and owners of aircraft with the goal of empowering our readers to improve their knowledge and enthusiasm for aviation. This AD also requires revising the AFMS to reflect each disabled unit. In installations where multiple Aspen EFDs provide redundancy, this may result in loss of all altitude and airspeed reference during the reset period. Any help from the Aspen/Avionics Guru's out there is greatly appreciated! S-TEC 3100: Version 1.4 Software Features | Genesys Aerosystems The converter is included with higher-end Evolution systems. 2) Fabricate shim from 2024-T3 aluminum with the four (4) mounting holes and 0.625" cable pass-thru drilled through. Im not sure I understand your statement. You will have to take it to a shop and have them look at it. For autopilot interfaces other than the digital TruTrak (which wires directly to the E5), the optional ACU is required. . The GPS is there really only for helping the attitude system of the Aspen internally check itself. ADS600-B, Part Numbers 200-0012 and 200-0013. Company. On February 25, 2020, Aspen Avionics, Inc. (Aspen), notified the FAA of 35 instances of software interacting with a graphics processing chip defect and causing an automatic reset to occur on Aspen EFD1000 Emergency Backup Display, EFD1000 Multi-Function Display, and EFD1000 Primary Flight Display systems. A) Use the 430's CDI page to fly a non-precision approach and hope I break out. Contact us to speak with an installation expert toll-free at 800-353-0370 for recommendations on aircraft avionics, flight instruments, pilot accessories and more. Aspen Avionics - massiv problems The video shows a paper to eight flying with him Aspen Avionics. The check in the EFD install manual Section 10.5.1.1 would have detected this before the test flight. I had the initial unit fail several times, but all in the first couple of weeks (May June 2008). We were recently notified that there have been numerous reports of Aspen EFD1000 PFD, EFD1000 MFD, EFD1000 EBD, and EFD500 MFD units with software version 2.9 and the ADS-B IN (FIS-B) Weather Interface option repeatedly resetting itself in-flight. Went for a test flight after an install of an Aspen . In the case of the entry-level E5, you might end up retaining the existing attitude indicator even though the STC doesnt require one. A couple of units failed completely random even had a DOA with one unit. Garmin GNC 420W/420AW, Garmin GNS 480, Garmin GTN 625/635/650/725/750, Garmin GPS 400W/500W, Garmin GNS 430W/430AW/530W/530AW. We are having almost identical issues in a 1994 Saratoga II HP with a legacy KAP150 autopilot, the EA100, and a GTN750 for a navigator. Display as a link instead, May 2022 - Present11 months. Problem is that Aspen does not have any loaner units that I have found which seems ridiculous considering Aspen's reliability issues which are well spoken on these forums. Is it not obvious to me and many others that there are intermittent problems that Aspen should be learning from failed units like this in 300 hours? FAA Removes Aspen Pro MAX PFD Backup Attitude Indicator Requirement Seattle Avionics | FlyQ EFB FAQ Airworthiness Directives; Aspen Avionics, Inc., Evolution Flight The FAA-approved software update 2.10.2 in March 2020. We guarantee the lowest price! Pulling the ADS-B circuit breaker as described in section 3.2.6 of the Flight Manual supplement, has been demonstrated to resolve the issue. On Tue, Apr 26, 2022 at 10:39 AM Andy Smith <, Need Help Diagnosing Aspen Intermittent AHRS Failure. Yes, Garmins G5 EFIS display is a logical choice for backing up the E5, but Garmins STC only permits the G5 to be installed as the primary AI, or for backing up other Garmin displays, including the TXi PFD. Now $4695.00/Each . At extreme pitch attitudes (above 30 degrees nose up or below 25 degrees nose down), red unusual attitude recovery chevrons come into view, pointing toward the horizon or ground as applicable. But sure, no harm in double checking that the SW version is current and that there really isn't any traffic info being fed to the unit. Hey PaulThere has been a lot of action lately from Aspen on this topic. Since we issued SAIB SW-18-31, additional analysis of the reports of uncommanded resets and the nature of the possible unsafe condition were evaluated, and we have determined that a more urgent safety need requiring AD action is necessary. The left knobs primary function is for setting the E5s course value, and its also used to bug an airspeed. While Aspen has been responsive in trying to resolve the issue I will describe below..I am posting here to try and get the word out to see if others are experiencing the same problems with the Aspen E5 to see if the community can shed some more light on what is going on with the Aspen E5. Your link has been automatically embedded. ). https://mooneyspace.com/search/?q=Aspen Andy&quick=1&updated_after=any&sortby=relevancy&search_and_or=and. ADS-B Market Size 2023 Will Touch A New Level In The - MarketWatch Mooneyspace.com . RSM's are sensitive to magnetic fields (and a strong field can damage an RSM). Join their team of dedicated and passionate professionals, fueled by the most powerful brand in private aviation, as they continue their mission of . View this and more full-time & part-time jobs in Aspen, CO on Snagajob. At Oshkosh, Aspen Avionics sponsors a base in the North 40 campground, offering an air-conditioned lounge and refreshments for the wide range of its 14,000-plus customers who fly into the show . should be prepared to deal with it should the issue arise. I recently found and reached out to another Aspen E5 customer that is going through similar problems with his new Aspen E5.I am looking to see if other Aspen E5 customers are experiencing similar issues to help find the root cause. Sent from my iPhone using Tapatalk Pro. Five hot keys to the right of the instruments navigation display toggle various features on and off, including the built-in GPS steering. Aspen calls the E5 a Dual EFI (electronic flight instrument) because its really a dual instrument, replacing the traditional mechanical attitude indicator and directional gyro in one split display. Earlier this year I took the plunge and did an avionics upgrade that included a new avidyne ifd440 and a new Aspen E5. The FAA requests that owners and operators of any ADS-B IN (FIS-B) enabled aircraft and the owners and operators of Aspen EFD flight display notify the FAA contact listed below of any similar events. Differences Between the AD and the Service Information:The service information specifies contacting an Aspen Avionics dealer to disable the ADS-B In function, whereas this AD requires contacting the FAA for approval of the procedure. I need a reliable EA-100, not a shop and more thousands of dollars in addition to what I gave already spent to resolve this same issue many others have/are having. they have all failed more than once. The right knob is for the heading bug (HDG), editing the selected altitude field (ALT) and baro (BARO) setting. He doesn't have traffic on his Aspen, making it doubly not applicable. Avidyne Corporation (U.S.) Garmin Ltd. Thales Group FreeFlight Systems Trig Avionics Ltd. L3 Technologies, Inc. Rockwell Collins, Inc. The New Mexico creator of the Evolution Flight Display that is the foundation of many glass cockpits now has deeper pockets. Our-Services - Green Mountain Avionics Aspens Scott Smith and their entire team are to be commended. One Arrow owner reporte d over a dozen removals of the EFD1000 to get it right. Garmin G5 Electronic Flight Instrument for Certificated Aircraft. The AIRO Group was created to pool the resources of several smaller companies into a larger entity with the chops to battle the big boys in emerging aerospace markets including unmanned aircraft of various sizes and capabilities, along with urban air mobility, and advanced avionics for defense and training. 35 instances of display systems automatically resetting have been reported. Thats not the case with the non-TSOd EFD1000 E5. What we find interesting here is that the older instruments are far more likely to be the ones in error. The Albuquerque, New Mexico, avionics firm known for delivering high-performance systems at lower price points announced February 2 that the $1,995 software . Americas owner-flown aircraft enthusiasts and active-pilot resource, delivered to your inbox! A year later, they were shipping and the field results were mixed: Capable technology but the installations werent going as smoothly as hoped and there was a higher-than-expected failure rate.New technology always takes some time to shake out the bugs, so now that there are hundreds of units out there in the field, we surveyed users to see if the reality is living up to the marketing copy.